WHAT CAN A TIMING BELT DO FOR ME?What's it do? The "technical" part The timing belt is essential to the operation of your car's engine. There are two main "shafts" in your engine, the Crankshaft, and the Camshaft. The timing belt connects these two shafts and makes them turn together at the right "time" (similar to the way a bicycle chain connects the pedals to the back wheel). This makes sure all the other goodies in the motor (like valves and pistons) are jumping and hopping at just the right "time". Hence the name..."timing" belt. What happens when it breaks? The timing belt is made of rubber, eventually it rots, and breaks. When this happens, your car stops. You have to get the car towed because it won't start until the engine is "re-timed", and the belt replaced. With some cars you can replace the belt and that's the end of it, with other cars, it's just the beginning of sorrows... The "Valve Benders" Some engines have a very close fit between the top of the piston and the bottom of the valve. When the engine is "in time" this close fit is just fine, because the piston is never up at the same time that the valve is down. BUT, when the timing belt breaks, the valves stop moving. Some of them are in the down position, and the piston, not aware of the little valve's predicament comes flying up and SMASHES into the poor little valve. The valve gets all bent out of shape over this and decides not to let your engine have any compression in that cylinder. Life with a bent valve Even if you replaced the timing belt at this point, the engine would still not run right, it would be very weak, and probably cough and hack because of the bent valve's poor health. You basically "have to" fix this condition or shoot the car to put it out of its misery. In order to fix this, a "valve job" is required. This costs anywhere from $600 to $1,500, depending on the make of your car, and on how many "extras" are discovered that you need once the engine is torn apart. The "good news" is.... You can save the little valves! All you have to do is replace the timing belt when it's due, instead of waiting until after it's dead. The cost may be high, but it's a whole lot cheaper than waiting for it to break. The timing belt should be replaced every 60,000 miles. Even if you don't drive much, you should replace it every 5 years because age and dry rot will weaken it just as much as mileage and use. Is mine a "Valve Bender"? Here is a list of valve bender engines. (There may be others we don't know about.) If your engine is on this list, please check your records soon to see when the belt was replaced last. If your car is not on this list, it probably does NOT bend valves. It is still important to replace the belt so you won't get stranded, though it's not as urgent to your wallet. (Some engines use a chain instead of a belt. Call us if you don't know which you have.)
The Benders
This list is old, gives a call and we'll look it up and see of your car is a bender. All right, how much is it? The "bare bones" job... The basic timing belt can run as low as $125 to $200 dollars depending on the make of the car. There are a few exceptions, even a basic job on a few types of vehicles can be $300 to $400. (See below list of the more expensive types.) If you do it "all the way right"... If you need some other things that often go with the job, it would be $300 to $400 for most cars. Some cars can reach $600 to $800. The more expensive models... Most V-6 engines; some 4 cylinders with dual timing belts; and some Dual Over Head Cam (DOHC) engines.
What are the "other
things" that go with it?
The following items should be checked and replaced, if needed, while changing the belt. The drive belts have to be taken off to do the timing belt. If they're old and cracked you can put new ones on for no more labor charge, just the cost of the belts. You have to take the timing belt off in order to get most water pumps off. A water pump has a little weep hole in it that the water comes out of when it goes bad. Even if it's not dumping water at the time, sometimes there's a trail of antifreeze, or deposits from where it's been coming out of that hole. If it shows signs of leaking, you can replace the pump while the timing belt's off and save a lot of money over doing the jobs separately. The oil seals behind the cam and crankshaft gears leak oil as they get some age on them. If they are leaking, the oil gets on the new timing belt, and deteriorates it, causing it to break prematurely, and then you're back putting another belt on, or bending valves. If these seals are leaking, it is a very good idea to replace them, since you already have the timing belt off, which is most of the labor required to get to the seals. The timing belt tensioner is sometimes bad. They can be worn, or the bearings can be going bad. If it "freezes up" on you, it will quickly break the new belt. If these things aren't bad, we don't mess with them, but if they are, it's very wise to fix them at the same time you do the timing belt. We're not trying to jack the price up, we just want to do a first class job that will save you money in the long run. So please, Check your Mileage.... If it's been 60,000 miles or five years, you should plan on getting that belt replaced. If you bought the car used, and don't know when it was last done, the situation is a bit sticky. Even if you brought it in for us to look at, unless the belt is really stretched or cracked, we can't tell by looking at it how old it is. We've seen belts break that don't look obviously dry rotted. So, in these cases, especially if it's a valve bender, it's better to play it safe than sorry. Replace it. Well, now you're a timing belt expert! Ready to make the world safe for
Does your life Need a new belt? By the way, there is a sorrow awaiting us all that is similar to the timing belt breaking on an engine, but far worse. Sin has rotted our timing belt to the core. We are already way out of time with God. One day when this life is over, and our physical bodies break, the piston of God will smash our valves, and for that there is no repair. Because the wages of sin is death. There is an answer! It's just like the belt. If we let God deal with our sin now, we won't have to be smashed after death. It's not too late until the belt breaks and our life is over. God has provided, not only a "new belt", but a whole new engine for our cars. Inside of man, there is a spirit, which is meant to be the true source of power in our lives. Sin has corrupted that "engine" or strength, and now we serve unrighteousness. Our new "belt" is Jesus! He took our old life, and our sin into Himself, on the cross, and absorbed all the punishment and wrath of God that was due US! By asking His forgiveness, and turning in your old engine (life) to Him, He will give you a new life, and you won't have to be afraid of the ultimate "Valve Bending" on judgment day. You can ride in this life with confidence. Not because you never had a rotten belt, but because Jesus gave you a new one! He wants your life... The cost is high, but it's a whole lot cheaper than waiting for your belt to break. If you want some help getting a new "engine" for life, give me a call at home or work. My home number is 757-547-7433. My name is Dyrell Hicks. You don't need to call me, but we all need to call God. Jesus said you can reach the Father through the Son. "Whoever calls upon the name of the Lord shall be saved." Romans 10:13. Call Him before it's too late.
©1994, Dyrell Hicks All rights reserved |
|
